Knowledge Of Safe Use Of Tractors

For the health and safety of you and your family, we remind all farm machinery operators to pay attention to the following matters when driving and operating tractors:

1.Newly purchased tractors should be registered according to regulations.

2.The tractor license plate should be kept clear and complete.

3.Tractors participating in cross regional operations require early maintenance.

4.Before starting the tractor, it is necessary to check whether the engine cooling water is sufficient, whether the external bolts of the locomotive walking system are tightened, whether the gear lever is in neutral position, and whether the hydraulic lifting handle is in a safe position. Special attention should be paid to checking whether all control levers, brakes, clutches, and electrical circuits are normal.

5.Before operating the tractor, the driver should check and maintain it according to the user manual to ensure that the machine is in good technical condition, meets relevant safety technical standards, and avoids air, oil, and water leaks.

6.Before operating the tractor, it is necessary to conduct a survey of the roads and fields to have a clear understanding of dangerous areas and obstacles.

7.When the tractor is working in the field, people must not leave the vehicle, stick to their posts, and it is forbidden to jump on or off; The agricultural tools should be securely attached, and turning is not allowed until all the tools have been raised. Reverse operation is strictly prohibited; Temporary 8. 8.Participants in the operation should wear work hats, with no exposed braids, and wear clothing that meets the requirements of the operation. Non operators are strictly prohibited from entering the work area, and operators are strictly prohibited from lying down or sleeping in the work area.

9.It is not allowed to dismantle or modify the safety protection device of the tractor at will. It is not allowed to start the machinery without the safety protection device installed.

10.When doing homework, focus your attention. If there are any abnormal phenomena or noises, stop the machine and turn off the engine in a timely manner to eliminate them, in order to avoid damaging the parts or causing personal injury.

11.When parking, the gear lever should be in neutral, and it is forbidden to disengage the clutch for a long time. Before the engine is turned off, the driver must not stay away from the locomotive.

12.During the process of turning, transferring, and reversing a tractor, the driver should pay special attention to pedestrian movements and obstacles.

13.When the tractor passes over the field embankment or ditch, the slope should be leveled or a gap should be excavated first, and the tractor should pass at low speed. Once a car gets stuck, do not increase the throttle and rush. Instead, dig out the floating mud around and at the bottom of the locomotive, fill it with straw, wooden boards, and other materials, and drive out at low speed or use other vehicles to pull it out.

14.It is strictly prohibited for tractors to exceed their service life or operate at overload. The tractor cab must be equipped with an effective fire extinguisher and securely placed on the cab.

15.It is strictly prohibited to drive or operate tractors under the influence of alcohol or excessive fatigue; During transportation operations, speeding and overloading are not allowed; It is not allowed to illegally carry people or mix people and goods.

16.It is prohibited to assemble or modify the tractor to change its original state, widen or raise it, or modify it to increase the transmission speed ratio of the tractor.

17.When driving on the road or transferring over long distances, strict adherence to road traffic safety regulations should be observed. When a malfunction or accident occurs on the road, the hazard warning flashers should be turned on and warning signs should be set up.

18.The power of supporting agricultural machinery should be matched with the power of the tractor and should not be overloaded.

19.During agricultural machinery operations, operators are not allowed to leave the locomotive and other personnel are strictly prohibited from approaching.

20.When reversing the tractor and coupling it with agricultural machinery, it is strictly prohibited for people to stand between the tractor and the agricultural machinery.

21.When connecting agricultural machinery to the power output shaft of a tractor, a protective cover should be added at the transmission shaft.

22.When the power output shaft rotates, the tractor cannot make sharp turns or lift the agricultural machinery too high.

23. In plowing, spinning, raking, plowing and other operations, the power connection parts, transmission devices, and protection should be taken into account

24.When the tractor is equipped with a suspended agricultural implement for long-distance driving, the locking handle should be used to lock the agricultural implement to prevent the control handle of the distributor from being touched during driving, which may cause the agricultural implement to suddenly fall and cause accidents.

25.Tractors participating in cross regional operations or night driving should be affixed with reflective signs or hung with reflective warning flags to improve the recognition of agricultural machinery on roads and reduce accidents.